Screening of sanitizer for foodborn pathogens in fresh-cut onions and the optimization of the sanitizing condition
-
摘要: 研究了几种消毒剂对鲜切洋葱表面食源性致病菌的杀灭效果,为提高洋葱等鲜切蔬菜的食用安全提供依据。用清水、次氯酸钠(200mg/L)、二氧化氯(10mg/L)、过氧化氢(20.0g/L)、酸化亚氯酸钠(1.0g/L)、过氧乙酸(80mg/L)、柠檬酸(10.0g/L)、乳酸(10.0g/L)以及乳酸(10.0g/L)结合55℃处理染菌的鲜切洋葱3min,以酸化亚氯酸钠效果最好,可分别减少3.19log CFU/g大肠杆菌O157∶H7,3.11log CFU/g单增李斯特菌和2.60logCFU/g鼠伤寒沙门氏菌。以李斯特菌为研究对象应用响应面优化酸化亚氯酸钠杀菌参数,优化结果为1.0g/L,处理2min。对酸化亚氯酸钠产生的药伤进行评价,发现处理后再经清水漂洗可避免药伤,保持理想的感官品质。
-
关键词:
- 消毒剂; /
- 鲜切洋葱; /
- 大肠杆菌O157∶H7; /
- 单增李斯特菌; /
- 鼠伤寒沙门氏菌;
Abstract: Effectiveness of multiple chemical sanitizers on reducing the food borne pathogens in fresh-cut onions was investigated to improve the food safety of fresh-cut vegetables.Fresh-cut onions were inoculated with food borne pathogens, then the inoculated onion dices were treated with water, sodium hypochlorite (200mg/L) , chlorine dioxide (10mg/L) , hydrogen peroxide (20.0g/L) , acidized sodium chlorite (1.0g/L) , peroxyacetic acid (80mg/L) , citric acid (10.0g/L) , lactic acid (10.0g/L) , and lactic acid at 55℃ (10.0g/L) for 3min respectively .The result showed acidified sodium chlorite produced a 3.19log CFU/g reduction for E.coli O157∶H7, a 3.11log CFU/g reduction for Listeria monocytogenes and a 2.60log CFU/g reduction for Salmonella typhimurium, achieving the best effect.To optimize the disinfection conditions, response surface experiment was applied and Listeria monocytogenes was taken as the research object, and the optimized treatment was 1.0g/L acidized sodium chlorite solution, rinsing for 2min.Assessing the effect of the acidized sodium chlorite on the fresh-cut onions found that acidized sodium chlorite treatment followed by water wash could keep desirable sensory quality. -
[1] Lynch M, Tauxe R, Hedberg C.The growing burden of foodborne outbreaks due to contaminated fresh produce:risks and opportunities[J].Epidemiology and Infection, 2009, 137 (3) :307-315.
[2] Gonzalez R J, Luo Y, Ruiz-Cruz S, et al.Efficacy of sanitizers to inactivate Escherichia coli O157∶H7on fresh-cut carrot shreds under simulated process water conditions[J].Journal of Food Protection, 2004, 67 (11) :2375-2380.
[3] Neal J A, Marquez-Gonzalez M, Cabrera-Diaz E, et al.Comparison of multiple chemical sanitizers for reducing Salmonella and Escherichia coli O157∶H7on spinach (Spinaciaoleracea) leaves[J].Food Research International, 2012, 45:1123-1128.
[4] Corbo M, Speranza B, Campaniello D, et al.Fresh-cut fruits preservation:current status and emerging technologies[J].Current research, Technology and Education topics in Applied Microbiology and Microbial Biotechnology, 2010 (2) :1143-1154.
[5] Sy K V, Mcwatters K H, Beuchat L R.Efficacy of gaseous chlorine dioxide as a sanitizer for killing Salmonella, yeasts, and molds on blueberries, strawberries, and raspberries[J].Journal of Food Protection, 2005, 68 (6) :1165-1175.
[6] Sy K V, Murray M B, Harrison M D, et al.Evaluation of gaseous chlorine dioxide as a sanitizer for killing Salmonella, Escherichia coli O157∶H7, Listeria monocytogenes, and yeasts and molds on fresh and fresh-cut produce[J].Journal of Food Protection, 2005, 68 (6) :1176-1187.
[7] Du J, Han Y, Linton R.Efficacy of chlorine dioxide gas in reducing Escherichia coli O157∶H7on apple surfaces[J].Food Microbiology, 2003, 20 (5) :583-591.
[8] Mahmoud B S M, Bhagat A, Linton R.Inactivation kinetics of inoculated Escherichia coli O157∶H7, Listeria monocytogenes and Salmonella enterica on strawberries by chlorine dioxide gas[J].Food Microbiology, 2007, 24 (7) :736-744.
[9] Materon L A.Survival of Escherichia coli O157∶H7applied to cantaloupes and the effectiveness of chlorinated water and lactic acid as disinfectants[J].World Journal of Microbiology and Biotechnology, 2003, 19 (8) :867-873.
[10] Akbas M, Lmez H.Inactivation of Escherichia coli and Listeria monocytogenes on iceberg lettuce by dip wash treatments with organic acids[J].Letters in Applied Microbiology, 2007, 44 (6) :619-624.
[11] Cantwell M, Hong G, Suslow T.Heat treatments control extension growth and enhance microbial disinfection of minimally processed green onions[J].Hortscience, 2001, 36 (4) :732-737.
[12] Benford D, Hill M, Jackson M, et al.Acidified sodium chlorite[C].Geneva:World Health Organization, 2008:4-8.
[13] Allende A, Mcevoy J, Tao Y, et al.Antimicrobial effect of acidified sodium chlorite, sodium chlorite, sodium hypochlorite, and citric acid on Escherichia coli O157∶H7and natural microflora of fresh-cut cilantro[J].Food Control, 2009, 20 (3) :230-234.
[14] Ukuku D O, Bari M, Kawamoto S, et al.Use of hydrogen peroxide in combination with nisin, sodium lactate and citric acid for reducing transfer of bacterial pathogens from whole melon surfaces to fresh-cut pieces[J].International Journal of Food Microbiology, 2005, 104 (2) :225-233.
计量
- 文章访问数:
- HTML全文浏览量:
- PDF下载量:
下载:
