Optimization of decolorization of polysaccharide from gentiana by response surface methodology
-
摘要: 采用响应面法优化聚酰胺对龙胆草多糖的脱色工艺。在单因素实验的基础上,选取龙胆草多糖脱色过程中的上样体积、上样流速和上样浓度为影响因素,以龙胆草多糖的脱色率和多糖保留率的综合评分(OD)为响应值,由Box-Behnken实验设计对龙胆草多糖的脱色工艺进行响应面分析,对龙胆草多糖的脱色工艺进行优化。结果表明,最佳脱色条件为:上样体积为5 BV,上样流速为2 BV/h,上样浓度为3.50 mg/mL。在此条件下,龙胆草多糖的脱色率为80.60%±0.91%,多糖保留率为86.28%±0.67%,其综合评分(OD)为0.8344,而模型预测的OD值为0.8756,两者误差较小。聚酰胺的重复利用实验表明,经过5次重复使用后,脱色率降为76.85%±0.59%,多糖保留率有所增大到98.32%±0.37%,循环使用效果较好,该优化工艺可靠。Abstract: The purpose was to optimize the decolorization process of polyamide for gentian polysaccharide by response surface methodology. On the basis of single factor test, sample volume, flow rate and the concentration of polysaccharide from gentian were selected as influential factors. The comprehensive score(OD)including the decolorization rate and polysaccharide retention rate was used as response value. The response surface analysis was carried out by Box-Behnken to optimize the process of decolorization process of gentian polysaccharide. The results indicated that the optimal decoloration process conditions were as follows:the sample size was 5BV, the sample flow rate was 2BV/h, and the sample concentration was 3.50 mg/mL. Under these conditions, the decolorization rate of polysaccharide was 80.60%±0.91%, and the retention rate of polysaccharide was about 86.28%±0.67%. The predicted values of the model was 0.8756 and the score(OD)was about 0.8344, which showed a small error between both of them. After 5 times of reuse use, the decolorization rate decreased to 76.85%±0.30% and the retention rate of polysaccharide increased to 98.32%±0.37%. So the polyamide has a good recycling effect, and the optimization process is reliable.
-
Keywords:
- response surface methodology /
- gentian /
- polysaccharide /
- decoloration /
- polyamide
-
[1] 江蔚新,江培,张晓燕,等.龙胆多糖的体内抗肿瘤作用研究[J].中成药,2008,30(10):1530-1532. [2] 沈涛,金航,王元忠,等.中药龙胆化学成分研究进展[J].安徽农业科学,2010,38(30):16868-16870 ,19874.
[3] 褚博文,张霁,李智敏,等.滇龙胆化学成分和药理作用研究进展[J].中国实验方剂学杂志,2016,22(13):213-222. [4] 江蔚新,何文顺,赵玺.龙胆多糖的降血脂作用的研究[J].黑龙江医药,2008,21(4):31-33. [5] Weirong Cai,Huiling Xu,Liangliang Xie,et al.Purification,characterization and in vitro anticoagulant activity of polysaccharides from Gentiana scabra Bunge roots[J]. Carbohydrate polymers,2016,140:308-313.
[6] Wang C Y,Zhang J,Wang Z Y.Optimization for the extraction of polysaccharides from Gentiana scabra Bunge and their antioxidant in vitro and anti-tumor activity in vivo[J].Journal of the Taiwan Institute of Chemical Engineers,2014,45(4):1126-1132.
[7] 王金宏.龙胆中植物多糖保肝、降血脂及免疫调节作用的研究[D].哈尔滨:哈尔滨商业大学,2012. [8] 江蔚新,张晓燕,何文顺.龙胆多糖对小鼠免疫功能的影响[J].黑龙江医药,2008,21(3):17-18. [9] 孟博,王臣,赵蔓.龙胆多糖对雏鸡免疫功能的影响[J].中国农村小康科技,2010,4:57-58. [10] 许惠玲.龙胆多糖的提取、分离纯化及其体外抗凝血活性研究[D].芜湖:安徽工程大学,2016. [11] 王晨瑜.龙胆多糖的制备及生物活性分析[J].抚顺:辽宁石油化工大学,2014. [12] 张丛丛,王莹,朴美子.响应面法优化黄秋葵多糖脱色工艺[J].食品工业科技,2014,35(19):251-263. [13] 阿力木江·穆提拉.阿克苏骏枣多糖的分离与纯化[D].乌鲁木齐:新疆大学,2014. [14] 陈义勇,窦祥龙,黄友如,等.常熟"沙家浜"绿茶多糖的纯化[J].食品与发酵工业,2011,37(11):121-124. [15] 玄光善,郑晓,孙钦勇,等.桦褐孔菌多糖的纯化及其单糖组成分析[J].中南药学,2014,12(10):981-984. [16] 陈义勇,黄友如,刘晶晶,等.金针菇下脚料多糖脱色工艺及其抑菌活性[J].食品研究与开发,2016,37(12):82-85. [17] 吴槿槿,夏聪华,李昌煜,等.猕猴桃根多糖的脱色工艺研究[J].中华中医药学刊,2010,28(12):2522-2525. [18] 殷凯.竹叶多糖提取、纯化及体外抗氧化研究-以长沙青皮竹为例[D].长沙:中南林业科技大学,2014. [19] 张伟丰.新疆阿魏菇多糖分离纯化、结构鉴定及活性研究[J].乌鲁木齐:新疆大学,2015. [20] 廖素媚.陈皮多糖的分离纯化、结构表征及其清除自由基活性研究[D].广州:广东药学院,2006. [21] 肖健,曹荣安,贾建,等.DEAE琼脂糖凝胶纯化龙胆多糖及其分子特性[J].食品科学,2016,37(15):130-135. [22] 杜晋平,贾陈忠,薛翼鹏,等.黄芩多糖纯化和硫酸酯化及红外光谱分析[J].2015,54(1):154-158. [23] G Pierre,M Graber,BA Rafiliposon,et al.Biochemical composition and changes of extracellular polysaccharides (ECPS) produced during microphytobenthic biofilm development[J]. Microbial Ecology,2012,63(1):157-169.
[24] 赵肖通,解军波,潘炳成,等.响应面分析法优化姬松茸多糖的脱色工艺[J].食品工业科技,2016,37(9):207-212. [25] 陈卓尔,李敏,王小静,等.大孔吸附树脂对维药恰麻古粗多糖脱色纯化工艺研究[J].应用化工,2017,46(2):230-239. [26] 郝功元,吴彩娥,杨剑婷,等.银杏花粉粗多糖脱色工艺研究[J].食品科学,2009,30(14):136-139. [27] 孔凡利,张名位,邝瑞彬,等.大孔吸附树脂对荔枝粗多糖的脱色条件研究[J].食品科技,2010(5):179-183. [28] 夏玮,吕庆,张文清,等.大孔吸附树脂脱桑叶多糖的研究[J].食品与发酵工业,2007,33(2):141-144. [29] 刘海霞,牛鹏飞,王峰,等.大孔吸附树脂对大枣多糖提取液的脱色条件研究[J].食品与发酵工业,2008,33(10):180-184. [30] 罗凯,黄秀芳,周毅峰,等.响应面实验优化复合酶法提取碎米荠多糖工艺及其抗氧化活性[J].食品科学,2017,38(4):237-242.
计量
- 文章访问数:
- HTML全文浏览量:
- PDF下载量:
下载:
